A new alternative to cosmetics preservation and the effect of the particle size of the emulsion droplets on preservation efficacy

Abstract

Objective

This study describes a new alternative combination preservative containing caprylyl glycol, phenethyl alcohol, and glyceryl caprylate and investigates the effects of the particle size of the emulsion droplet on the antimicrobial activity of the said blend in the formulation.

Methods

The antimicrobial activity of the ingredients and the blend were determined via MIC, MBC, MFC, and fractional inhibitory concentration (FIC) determination using the broth microdilution method. The blend inhibited the microorganism contamination of the oil-in-water emulsion, and its performance was affected by the particle size of the emulsion droplet, as shown by the in vitro microbial challenge test.

Results

Results show that the MIC/MBC/MFC values of the blend were lower than those of any of the ingredients used alone. Any two of the ingredients presented no antagonistic activities against all the tested microorganisms, and synergism or additive effects were also observed. The challenge test also showed that the action of the blend against bacteria and yeast was only 0.3% and 0.2%, respectively, and mold was completely inhibited at 1.4%, meeting the requirements of the PCPC and European Pharmacopoeia. The results showed that antimicrobial activity was gradually enhanced when the particle size of the emulsion droplets increased significantly in the range of 100–900 nm. A positive correlation was found between antimicrobial activity and particle size.

Conclusion

The synergistic performance of caprylyl glycol, phenethyl alcohol, and glyceryl caprylate and the antimicrobial activity of their blend suggest that their combination is effective and exhibits broad-spectrum antimicrobial activity. Furthermore, the results show a positive correlation between the antimicrobial activity of the preservative and the particle size of the emulsion droplets in the range of 100–900 nm, when the same concentration of the blend is used in the same formulation. The particle size of the emulsion droplets is demonstrated to be a newly-discovered factor that influences the preservation of cosmetic products.

This article is protected by copyright. All rights reserved.

from #ENT via xlomafota13 on Inoreader http://ift.tt/1TuCeKt
via IFTTT